Product ID:ISOPROPYL ALCOHOL
MSDS Date:08/01/1993
FSC:6810
NIIN:00-753-4993
MSDS Number: BVGLX

Emergency Phone: 206-889-3712, CHEMTREC 800-424-9300

Info Phone: 206-889-3400

Preparer: JEANE SINCLAIR

Cage: 0STM5

Telephone: 425-889-3400/425-889-3617

Cage: 0STM5

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: >99%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION:IRRITATION OF THE NOSE &
THROAT. HIGHER CONCENTRATIONS MAY CAUSE COMA & DEATH.
EYES:IRRITATION, CORNEAL BURNS. SKIN:DRYNESS. INGESTION:LARGE
AMOUNTS CAUSE HEADACHE, NAUSEA, VOMITING, STOMAC H CRAMPS,
UNCONSCIOUSNESS, DEATH. CHRONIC- DERMATITIS.
Effects of Overexposure:IRRITATION OF EYES, SKIN AND NOSE; HEADACHE,
NAUSEA, VOMITING, UNCONSCIOUSNESS, COMA AND DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS, EYE
PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE.

First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
APPLY SKIN CREAM IF DEFATTING OF SKIN OCCURES. INHALATION: REMOVE
TO FRESH AIR AT ONCE. RESUSCITATE IF BREATHING STOPPED. GET MEDICAL
ATTE NTION. EYE: IMMEDIATELY FLUSH WITH WATERFOR 15 MINUTES WHILE
HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET
IMMEDIATE MEDICAL ATTENTION. DO NOT INDUCE VOMITING. MED: GIVE
GASTRIC LAVAGE.

Flash Point Method:TCC
Flash Point:53.0F,11.7C
Lower Limits:2.0%
Upper Limits:12.7%
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE,
ALCOHOLIC FOAM. DO NOT USE DIRECT WATER SPRAY.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING FIRE. USE WATER SPRAY TO
COOL NEARBY FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL AND BE IGNITED BY PILOT
LIGHTS, FLAMES, SPARKS, HEATERS, AT DISTANCES FROM THE HANDLING
POINT.

Spill Release Procedures:EXTINGUISH IGNITION SOURCES. BE SURE ALL
HANDLING EQUIPMENT IS ELECTRICALLY GROUNDED. SMALL SPILL:MOP UP &
PLACE IN DOT APPROVED CONTAINERS. LARGE SPILL:DIKE W/SOIL OR OTHER
NON-COMBUSTIBLE MATERIAL & PUMP INTO DOT CONTAINER. KEEP OUT OF
SEWERS, ETC.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, AND OPEN
FLAMES. STORE IN COOL, DRY, WELL-VENTILATED PLACE AWAY FROM
INCOMPATIBLE MATERIAL. VENT CONTAINER FREQUENTLY.
Other Precautions:VENT MORE OFTEN IN WARM WEATHER. USE ONLY
NON-SPARKING TOOLS AND ELECTRICALLY GROUND ALL EQUIPMENT WHEN
HANDLING THIS PRODUCT. DO NOT USE PRESSURE TO EMPTY CONTAINERS.
EMPTY CONTAINERS CAN HAVE RESIDU ES, GASES & MISTS. DISPOSE
PROPERLY.

Respiratory Protection:BASED ON CONTAMINATION LEVELS IN THE WORK PLACE.
FOR EXAMPLE: HALF MASK AIR PURIFYING CARTRIDGE RESPIRATOR OR
SUPPLIED AIR RESPIRATOR.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED.
Protective Gloves:RUBBER
Eye Protection:CHEMICAL GOGGLES UNLESS RESPIRATOER WORN
Other Protective Equipment:RUBBER APRON, RUBBER BOOTS, IMPERVIOUS
CLOTHING.ETY SHOWER.
Work Hygienic Practices:EYE WASH FOUNTAIN, QUICK DRENCH SHOWER.
Supplemental Safety and Health

HCC:F2
NRC/State Lic Num:NONE
Boiling Pt:=82.C, 179.6F
B.P. Text:180F,82C
Melt/Freeze Pt:M.P/F.P Text:-127F,-88C
Vapor Pres:33 DEG.C?!
Vapor Density:2.1
Spec Gravity:0.79
Evaporation Rate & Reference:2.83 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, ALCOHOLIC ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALUMINUM, ACETALDEHYDE, CHLORINE, ETHYLENE OXIDE,
HYPOCHLORUS ACID, ALDEHYDES.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:MAY LIBERATE CARBON MONOXIDE OR CARBON
DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:CONSULT APPROPRIATE FEDERAL, STATE & LOCAL
REGULATORY AGENCIES TO ASCERTAIN PROPER DISPOSAL PROCEDURES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.